ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
– Switch on ignition.
– “PASSENGER AIRBAG OFF” display -1- must also light up
after self-test (passenger airbag deactivated).
– Switch off ignition.
– Using the ignition key, turn switch to position “PASSENGER
AIRBAG ON”.
– Switch on ignition.
– “PASSENGER AIRBAG OFF” warning lamp goes out after
self-test (passenger airbag activated).
– Switch off ignition.
4.8
Tyres: checking condition, wear pat‐
tern, tyre pressure and tread depth
Checking condition of tyre ⇒ page 27 .
Checking wear pattern ⇒ page 27
Tread depth (including spare wheel): check ⇒ page 28 .
26
4. Descriptions of work
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
General notes ⇒ page 28
Tyre pressures ID.4 ⇒ page 30
Special tools and workshop equipment required
♦ Tyre inflator -VAS 5216-
4.8.1
Tyres: checking condition
Tests at delivery inspection
– Check tyre side walls and treads for damage and foreign
bodies such as, for example, nails or glass splinters.
Tests at service
– Check tyre side walls and treads for damage and foreign
bodies such as, for example, nails or glass splinters.
– Check tyres for cupping, one-sided wear, porous side walls,
cuts and punctures.
– Ensure direction of rotation is correct and tyres are not fitted
wrong way round.
– Check for ageing of tyres.
Note
♦ For indications of tyre ageing, see Wheels and Tyres Guide.
⇒ Wheels and Tyres Guide - General Information; Rep.
gr. 44; Information about tyres; Tyre ageing
♦ If damage is determined, always check to see if a new tyre
should be fitted.
4.8.2
Wear pattern: checking
The wear pattern on the front tyres will indicate, for example, if
toe and camber settings should be checked:
♦ Feathering on tread indicates incorrect toe setting.
♦ One-sided tread wear is mainly attributed to incorrect cam‐
ber.
If wear of this nature is detected, determine cause by checking
wheel alignment (repair measure).
4. Descriptions of work
27
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
4.8.3
Tyre tread depth (including spare
wheel): checking
– Check tyre tread depth.
Minimum tread depth: 1.6 mm
Note
♦ This figure may vary according to legislation in individual
countries. Ask your importer.
♦ The minimum tread depth is reached when the tyres have
worn down level with the 1.6 mm high tread wear indicators
-arrows- positioned at intervals around the tyre.
♦ If the tread depth is approaching the minimum allowed
depth, inform the customer.
4.8.4
General information
NOTICE
For safety reasons, only tyres of same type and tread pattern
should be fitted on a vehicle!
– Observe approved wheel and tyre combinations. ⇒ Wheels
and tyres guide; Rep. gr. 44; Wheels, tyres, vehicle geom‐
etry; Wheel and tyre combinations
28
4. Descriptions of work
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
Note
♦ Tyre pressures for the relevant model can also be found on
a sticker. It is attached to the inside of tank flap or to B-pillar.
♦ The tyre pressures listed on the sticker are valid for cold
tyres. Do not reduce increased pressures of warm tyres.
♦ Depending on the vehicle, the sticker may also contain in‐
formation on the comfort tyre pressure. The comfort tyre
pressure facilitates improved driving comfort.
♦ Adjust the tyre pressure to suit the vehicle load. For delivery
inspections or repairs, the partial load tyre pressure is to be
used.
♦ If no inflation pressure is shown for the spare wheel, then
inflate the spare wheel to the highest inflation pressure for
the vehicle.
♦ Note that a basic setting is to be performed on vehicles
with Tyre Pressure Loss Indicator each time the pressure is
changed ⇒ page 52 .
Winter tyres
Note
♦ Important information about winter tyres recommended by
Volkswagen can be found in ⇒ Wheels and tyres guide;
Rep. gr. 44; Wheels, tyres, wheel alignment; Wheel and tyre
combinations.
♦ If winter tyres are fitted, a sticker indicating the speed limit
must be attached in the interior where it is visible for the
customer.
♦ For winter tyres, the tyre pressure does not have be in‐
creased. However, this only applies if the winter tyre used
corresponds exactly to the standard summer tyre size and
the speed index is no higher than “H”. If this is not the case,
please refer to the recommendation of the tyre manufactur‐
er.
4. Descriptions of work
29
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
4.8.5
Tyre pressures ID.4
Note
♦ During delivery inspection, check that tyre inflation pressure
sticker is fitted. If the sticker is missing, order a new sticker
through ETKA.
♦ The mandatory tyre pressures for the respective model can
be found on a sticker attached to the inside of the tank flap
or to the B-pillar.
♦ If the inflation pressure sticker is missing, proceed as fol‐
lows:
♦ Locate correct part number for respective vehicle in ETKA.
♦ Using part number, determine respective inflation pressures
in tyre inflation table.
♦ Uniform pressure: if tyre sizes are not shown for a part num‐
ber, then a uniform pressure is valid for all authorised wheel/
tyre combinations. ⇒ Wheels and tyres guide; Rep. gr. 44;
Wheels, tyres, vehicle geometry; Wheel and tyre combina‐
tions
Check tyre pressure using tyre inflator -VAS 5216-, correct if
necessary.
Part number -11A 010 000-
ID.4
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/60 R18
235/55 R19
235/50 R20
235/45 R21
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
---
---
---
---
---
---
---
---
270/2.7/39
250/2.5/36
250/2.5/36
250/2.5/36
290/2.9/42
280/2.8/41
280/2.8/41
280/2.8/41
Part number
ID.4
-11A 010 000 G-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/55 R19
235/50 R20
235/45 R21
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
250/2.5/36
---
---
---
---
---
---
250/2.5/36
250/2.5/36
250/2.5/36
290/2.9/42
290/2.9/42
290/2.9/42
Part number
ID.4
-11A 010 000 G-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/55 R19
255/50 R19
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
---
---
---
---
---
---
250/2.5/36
---
---
250/2.5/36
290/2.9/42
30
4. Descriptions of work
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
Part number
ID.4
-11A 010 000 G-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/50 R20
255/45 R20
235/45 R21
255/40 R21
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
---
---
---
---
---
---
---
---
---
250/2.5/36
---
---
250/2.5/36
---
250/2.5/36
---
250/2.5/36
---
250/2.5/36
---
290/2.9/42
---
290/2.9/42
Part number
ID.4
-11A 010 000 K-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
Front
Rear
Front
Rear
Front
Rear
235/55 R19
255/50 R19
235/50 R20
255/45 R20
235/45 R21
255/40 R21
250/2.5/36
---
---
---
---
---
---
---
---
---
---
---
---
---
270/2.7/39
---
---
250/2.5/36
---
250/2.5/36
---
250/2.5/36
---
250/2.5/36
---
---
270/2.7/39
---
270/2.7/39
---
310/3.1/45
---
310/3.1/45
---
250/2.5/36
310/3.1/45
Part number -11A 010 000 L-
ID.4
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
Front
Rear
Front
Rear
Front
Rear
235/55 R19
255/50 R19
235/50 R20
255/45 R20
235/45 R21
255/40 R21
270/2.7/39
---
---
---
---
---
---
---
---
---
---
---
---
---
310/3.1/45
---
---
270/2.7/39
---
270/2.7/39
---
270/2.7/39
---
270/2.7/39
---
---
310/3.1/45
---
310/3.1/45
---
320/3.2/46
---
320/3.2/46
---
270/2.7/39
320/3.2/46
Part number
ID.4
-11A 010 000 P-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/55 R19
255/50 R19
235/50 R20
255/45 R20
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
---
---
---
---
---
---
---
---
---
250/2.5/36
---
---
250/2.5/36
---
270/2.7/39
---
270/2.7/39
---
250/2.5/36
---
290/2.9/42
---
290/2.9/42
4. Descriptions of work
31
ID.4 2021 ➤, ID.5 2021 ➤
Maintenance - Edition 11.2021
Part number
ID.4
-11A 010 000 Q-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/55 R19
255/50 R19
235/50 R20
255/45 R20
Front
Rear
Front
Rear
Front
Rear
250/2.5/36
---
---
---
---
---
---
---
---
---
270/2.7/39
---
---
250/2.5/36
---
270/2.7/39
---
270/2.7/39
---
270/2.7/39
---
310/3.1/45
---
310/3.1/45
Part number
ID.4
-11A 010 000 M-
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/55 R19
255/50 R19
235/50 R20
255/45 R20
Front
Rear
Front
Rear
Front
Rear
270/2.7/39
---
---
---
---
---
---
---
---
---
310/3.1/45
---
---
270/2.7/39
---
270/2.7/39
---
270/2.7/39
---
310/3.1/45
---
320/3.2/46
---
320/3.2/46
Part number -11A 010 000 L-
ID.4
Half payload
kPa/bar/psi
Half load, comfort
kPa/bar/psi
Full payload
kPa/bar/psi
Tyre size
235/45 R21
255/40 R21
Front
Rear
Front
Rear
Front
Rear
270/2.7/39
---
---
---
---
---
---
280/2.8/41
---
---
270/2.7/39
310/3.1/45
4.9
Brake system: changing brake fluid
Special tools and workshop equipment required
♦ Torque wrench
♦ Brake filling and bleeding equipment -VAS 6860-
32
4. Descriptions of work
2024 VW ID.4 Owner's Manual
